2001 roadking excessive crankcase vapor venting?

just bought an 01 injected roadking. The crankcase vent hose seems to be putting too much vapor into the air cleaner. To the point that condensation developes on the inside of the air cleaner cover and literally sprays out while riding. after parking the bike it drips water for about 15 minutes. i was told it could be an umbrella seal but i would think that would let oil into the cylinder causing the bike to smoke.any ideas would be appreciated.
i should add that while there is evidence of moisture “in” the engine (bottom of oil cap has a small amount of milky deposit), the oil itself shows no signs of water… no froth or bubbles, and is very clean… with the amount of water i have coming out of the air cleaner one would expect a good amount of water in the oil.

Hi M5,

The Umbrella Valve actually is most likely cause.

It’s mounted at very top of engine,,internally.

It’s supposed to act like a 1-way Check Valve.

When Pistons go Down,,that compresses air in the CrankCase.
That Pressure is Supposed to be vented to atmosphere by the Umbrella seal.

When Pistons begin coming UP,,,,That Creates a Large Vacuum on the Crankcase.

That Vacuum is supposed to be BLOCKED from the Atmosphere by the Umbrella Seals Closing.

:Ideally,,,,the Valves hold Tight and the Vacuum is maintained in the Crankcase.

Untill Pistons head DOWN again.
But This time,,,there’s a Vacuum in the cases,,,So Nothing to Compress.
Any pressure that may rise,,,will again Open the Umbrella and vent.

When the U.V. Fails to Seal Closed,,,
Atmospheric Air is inhaled.
That air is moisture laden.

When it gets Compressed in the Engine by Piston Travel,,,that Moisture Condenses.

Very Common example of the principle is Air Compressors.
They have InLine Water/Moisture filters to keep Air OUT of the Output Pressure Lines.
And Drains on the Air Tank to drain the accumulated Moisture.

In your Bike,,,as with any pressurized gas,,,,it COOLS when it Expands.

The Vent Holes are Very Small to pass all that air volume thru.
That will make Any Moisture “Evaporate”—turn to Vapor.

It’s Heated from Engine and “steaming” already.
Squeeze it thru that little vent hole,,,,,under all that Pressure,,,then as it Exits that Orifice it’s GONNA make a Water Spray.

………………….
The Cure is to Prevent Atmospheric Air from entering CrankCase.
Otherwise it’s ACTUALLY sucking water out of thin air.
And has an Ample supply to draw from.

Blocking that Air Aspiration in Crankcases is the Job of the Umbrella Valve.

If You got Excess water coming from the Engine,,,It’s GOTTA be coming from Somewhere.
Bad Umbrella Seals are Main Path for that,,,
and are a Common Problem.

Replace Them and it will solve the Problem of all that water.

………………………………………………….

You may be interested to read about these things.

http://www.et-performance.com/kv.html#EVO

http://www.et-performance.com/faq.html

……………………………………………………
I always hesitate to answer H-D questions.

Majority of people are too defensive against any identification of a problem.They take it as Bashing.

Or,,they’re Experts,,,and perfectly indoctrinated to repeat the mantra “They All Do That,,”That’s How a Harley Is”,,etc,and so on.

It’s YOUR Bike,,
YOUR Money.
Makes me no difference what so ever.

What IS important to ME ,,,is that when someone asks a question,,,they get a factual Answer.

YOU mentioned there’s Water pouring out of your engine.
That’s Not “the engine”.

It’s Coming out of the OIL.

The Water You see was Distilled from Atmosphere,,,
Condensed Internally to Liquid.
And ACTS like Any Liquid that would enter the Engine,,,Including OIL .
The water Drains Down into Sump WITH the Oil,,,and gets circulated around.

Engine Heat Boils it back Out(EVAPORATES it out,,,actually)

And it’s Blown Out of the CrankCase Vent under High PSI thru a Restricted Orifice.

I mean,,,You SEE it your self.

Dont let anyone make you think that’s Normal,,or “They All Do That”,,,,or lead you to accept any myths about what’s happening to your engine.

What’s Happening is,,,You’re riding around with Water Contaminated OIL.
Water FLOATS oil,,,as in OFF of Surfaces.

Even if it Evaporates Out as you run,,,
You are Steadily “Refilling It with Water” from atmospehric condensation.

Yep,,”It’s Broke”
And Yes,,It’s a Known Issue.
Nope,,it dont matter How many “All Do That”….

If YOU want YOUR bike to stay healthy,,,,it NEEDS to be Fixed.

Simply Replacing the Umbrella Seals will do,,,they work Ok,and will last a while.

Or,You have some Upgrade/Mod options.

Either way beats cruising around with a bunch of water contaminating your engine oil.

It’s not what’s coming OUT your motor,,
It’s about whats getting IN.
The Umrella’s job is to Stop It.
It’s simply Not doing it’s Job

Good Luck

15 minutes (2001) trailer

Sesame Street - Kids' Favorite Songs 2 $4.90 Somewhere into the so-so "Itsy Bitsy Spider" segment, the sinking feeling that Kids' Favorite Songs 2 is strictly sequel material sets in. This is a march down Sesame Street on a slow day, when the loopy monster misunderstandings and goofball gags miss a rare beat or two. Still, making merry is what the Sesame crew does best, and they succeed here, if on a less brilliant level than we've come...

The Science of Fitness with Tamilee - I Want That Body! $3.00 For those who want their left brain to get a workout along with their bodies, Tamilee Webb's Science of Fitness series, including I Want That Body!, is are just what the personal trainer and professor ordered. Webb, an appealing and inspiring fitness instructor, includes scientific demonstrations conducted in a lab, showing how her exercises target each muscle group. This disc contains workouts f...

TaeBo II: Get Ripped Basic Workout $14.98 This two-video set by Billy Blanks includes two 30-minute Tae-Bo workouts. Although they're "basic" by Tae-Bo standards, they're not wimpy. In the first workout, Blanks starts with a warm-up and stretch, then he takes you to the floor for a killer muscle-conditioning routine for the abdominals, legs, and buttocks. Then you get onto your feet for a kickboxing routine. Blanks pre-teaches the moves s...

All Terrain TerraSport SPF15 Natural Sunscreen Lotion (3- Ounce) $2.99 All Terrain designed TerraSport specifically to protect you against sun damage during land related activities, from skiing the backcountry to planting in your garden. TerraSport is water and sweat resistant. However, this unique formula allows the skin to breathe naturally, helping to avoid unnecessary overheating. It goes on dry so you won't lose your grip on your bike, climbing equipment, hiking...

NatureBright Clarity Skin Rejuvenation Light $249.99 Achieve the smooth, bright look of a spa facial with the NatureBright Clarity Rejuvenation Light. Offering salon-quality skin treatment, this portable device uses therapeutic red and blue lights to stimulate healthy skin growth and fight blemish-causing bacteria. Address fine lines and wrinkles, age spots, skin redness, and blemishes with this safe, painless light.The Clarity Rejuvenation LightAt ...